How to remove and install the timing chain cover,Timing Chain and Timing Chain Tensioner in 2.0L,2.3L and 2.5L engine on Ford Fusion?

To remove the timing cover, first disconnect the negative battery cable. Loosen the water pump pulley bolts, then remove the drivebelt and drivebelt idler pulley along with the water pump pulley. Next, remove the crankshaft pulley, ensuring the engine remains at TDC with the valve cover removed. Disconnect the Crankshaft Position (CKP) sensor electrical connector and remove the sensor, noting that a new sensor must be installed each time it is removed, using the special alignment tool provided. Support the engine from above and raise it enough to remove the right engine mount. Disconnect the electrical connector to the power steering pressure switch, unbolt the power steering pump without disconnecting the hoses, and remove the crankshaft front oil seal. Finally, remove the bolts and the timing cover. For installation, reverse the removal steps while ensuring to clean the mating surfaces, apply a 2.5 mm bead of RTV sealant within four minutes, tighten the bolts in sequence, install a new crankshaft front oil seal, re-time the engine, and use a new crankshaft position sensor with the alignment tool, ensuring not to tighten the sensor mounting bolts until the tool is in place. To remove the timing chain and tensioner, first remove the timing cover, then compress the timing chain tensioner and insert a pin to hold it in the compressed position, being cautious not to compress the ratchet mechanism. Remove the two tensioner mounting bolts and the tensioner, followed by the loose timing chain guide and timing chain. If necessary, remove the left chain guide and camshaft sprockets. For installation, remove the camshaft alignment tool if installed, loosen but do not remove the camshaft phaser and sprocket bolts, and hold the camshaft while turning the sprocket bolt. Install the left chain guide if removed, followed by the timing chain and right chain guide. Install the timing chain tensioner, tighten the fasteners, and remove the pin to release the tensioner. Finally, install the camshaft alignment tool and tighten the camshaft sprocket bolts while holding the camshafts in place. The timing cover can now be installed.

Genuine Ford Fusion Timing Chain Tensioner

Engine Timing Chain Tensioner

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

21 Timing Chain Tensioners found

View related parts
Ford Fusion Tensioner - Timing Chain
Part Number: BA5Z-6L266-B
$54.95 MSRP: $80.33
You Save: $25.38 (32%)
ADD TO CART
Product Specifications
- Other Name: Tensioner
- Replaces: BA5Z-6L266-A
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2011-2012 Ford Fusion | 6 Cyl 3.5L DOHC VCT SMPI | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner - Timing Chain
Part Number: 9L8Z-6L266-A
$55.29 MSRP: $80.83
You Save: $25.54 (32%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Tensioner
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2010-2012 Ford Fusion | 6 Cyl 3.0L OHC Duratec | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner - Timing Belt
Part Number: GB5Z-6K254-A
$39.56 MSRP: $56.83
You Save: $17.27 (31%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Tensioner
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2020 Ford Fusion | 4 Cyl 2.0 L FULL HYBRID EV-GAS (FHEV), 4 Cyl 2.0 L GAS, 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV), 4 Cyl 2.5 L FLEX, 4 Cyl 2.5 L GAS
View related parts
Ford Fusion Tensioner - Timing Belt
Part Number: 7T4Z-6K254-B
$44.57 MSRP: $65.17
You Save: $20.60 (32%)
Ships in 1 Business Day
ADD TO CART
Product Specifications
- Other Name: Tensioner
- Manufacturer Note: Primary
- Replaces: 7T4Z-6K254-CA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2012 Ford Fusion | 6 Cyl 3.5L DOHC VCT SMPI | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner - Timing Chain
Part Number: FT4Z-6L266-B
$46.28 MSRP: $66.50
You Save: $20.22 (31%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Tensioner
- Manufacturer Note: (RH)
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2017-2019 Ford Fusion | 6 Cyl 2.7L | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F55, 6-Speed Manual Transmission - B6, ECVT Auto Trans Power Split, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Arm - Timing Chain Tensioner
Part Number: 6M8Z-6K255-A
$23.03 MSRP: $33.67
You Save: $10.64 (32%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Guide, Tensioner Arm, Tensioner Guide
- Manufacturer Note: Used With 38 Tooth Upper Gear
- Replaces: 1L5Z-6K255-AA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2020 Ford Fusion | 4 Cyl 2.3L, 4 Cyl 2.5 L FLEX, 4 Cyl 2.5 L GAS, 4 Cyl 2.5L Duratec (110kW/150PS), 4 Cyl 2.5L Duratec FFV (125kW/170PS), 4 Cyl 2.5L Duratec HE PFI, 4 Cyl 2.5L PFI Gas/Electric | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F55, 6-Speed Manual Transmission - B6, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, ECVT Auto Trans Power Split, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner
Part Number: 7T4Z-6K254-BA
$43.96 MSRP: $63.17
You Save: $19.21 (31%)
Ships in 1 Business Day
ADD TO CART
Product Specifications
- Manufacturer Note: Secondary
- Position: Driver Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2012 Ford Fusion | 6 Cyl 3.5L DOHC VCT SMPI | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner - Timing Belt
Part Number: 7T4Z-6K254-AA
$36.78 MSRP: $67.00
You Save: $30.22 (46%)
Ships in 1 Business Day

Out of Stock
Product Specifications
- Other Name: Tensioner
- Manufacturer Note: Secondary
- Position: Passenger Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2012 Ford Fusion | 6 Cyl 3.5L DOHC VCT SMPI | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Arm - Timing Chain Tensioner
Part Number: BA5Z-6K255-A
$18.49 MSRP: $26.33
You Save: $7.84 (30%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Chain Guide, Tensioner Arm
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2011-2012 Ford Fusion | 6 Cyl 3.5L DOHC VCT SMPI | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Guide
Part Number: BA5Z-6B274-A
$26.33 MSRP: $37.50
You Save: $11.17 (30%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Chain Guide, Tensioner Arm
- Position: Driver Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2011-2012 Ford Fusion | 6 Cyl 3.5L DOHC VCT SMPI | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner - Timing Chain
Part Number: FT4Z-6L266-A
$38.61 MSRP: $70.33
You Save: $31.72 (46%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Tensioner
- Manufacturer Note: (LH)
- Position: Driver Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2017-2019 Ford Fusion | 6 Cyl 2.7L | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F55, 6-Speed Manual Transmission - B6, ECVT Auto Trans Power Split, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner
Part Number: CJ5Z-6K254-A
$9.56 MSRP: $13.62
You Save: $4.06 (30%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Position: Driver Side
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2013-2020 Ford Fusion | 4 Cyl 2.0 L GAS, 4 Cyl 2.0L EcoBoost (200PS), 4 Cyl 2.0L EcoBoost (240PS) | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F55, 6-Speed Manual Transmission - B6, ECVT Auto Trans Power Split, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Arm - Timing Chain Tensioner
Part Number: 1S7Z-6K255-AE
$19.49 MSRP: $28.50
You Save: $9.01 (32%)
ADD TO CART
Product Specifications
- Other Name: Tensioner Arm, Tensioner Guide
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2013-2020 Ford Fusion | 4 Cyl 2.0 L FULL HYBRID EV-GAS (FHEV), 4 Cyl 2.0 L PLUG-IN HYBRID EV-GAS (PHEV), 4 Cyl 2.0L Duratec Hybrid (130kW) | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F55, 6-Speed Manual Transmission - B6, ECVT Auto Trans Power Split, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Arm - Timing Chain Tensioner
Part Number: FT4Z-6K255-A
$17.33 MSRP: $25.33
You Save: $8.00 (32%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Guide, Tensioner Arm
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2017-2019 Ford Fusion | 6 Cyl 2.7L | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F55, 6-Speed Manual Transmission - B6, ECVT Auto Trans Power Split, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner - Timing Belt
Part Number: 7T4Z-6K254-CA
$45.36 MSRP: $65.17
You Save: $19.81 (31%)
Ships in 1 Business Day
ADD TO CART
Product Specifications
- Manufacturer Note: Primary
- Replaced by: 7T4Z-6K254-B
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2009 Ford Fusion | 6 Cyl 3.5L DOHC VCT SMPI | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner - Timing Chain
Part Number: BA5Z-6L266-A
$54.95 MSRP: $80.33
You Save: $25.38 (32%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Replaced by: BA5Z-6L266-B
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2011 Ford Fusion | 6 Cyl 3.5L DOHC VCT SMPI | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Timing Chain Tensioner Arm
Part Number: K2GZ-6K255-A
$26.78 MSRP: $34.83
You Save: $8.05 (24%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Arm - Timing Chain Tensioner; Guide, Tensioner Arm
- Replaces: CJ5Z-6K255-A
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2013-2020 Ford Fusion | 4 Cyl 2.0 L GAS, 4 Cyl 2.0L EcoBoost (200PS), 4 Cyl 2.0L EcoBoost (240PS) | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F55, 6-Speed Manual Transmission - B6, ECVT Auto Trans Power Split, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner
Part Number: FT4Z-6K254-A
$14.02 MSRP: $20.50
You Save: $6.48 (32%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Chain Tensioner, Inlet Tube
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2017-2019 Ford Fusion | 6 Cyl 2.7L | 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F55, 6-Speed Manual Transmission - B6, ECVT Auto Trans Power Split, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner - Timing Chain
Part Number: YF1Z-6L266-BA
$52.44 MSRP: $76.00
You Save: $23.56 (31%)
ADD TO CART
Product Specifications
- Other Name: Tensioner
- Position: Passenger Side & Driver Side
- Replaces: YF1Z-6L266-AA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2006-2009 Ford Fusion | 6 Cyl 3.0L DOHC EFI | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive
View related parts
Ford Fusion Tensioner - Timing Belt
Part Number: 1S7Z-6K254-AA
Product Specifications
- Manufacturer Note: Camshaft chain tensioner arm
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2006-2019 Ford Fusion | 4 Cyl 2.0L Duratec Hybrid (130kW) , 4 Cyl 2.3L, 4 Cyl 2.5L Duratec (110kW/150PS), 4 Cyl 2.5L Duratec FFV (125kW/170PS) , 4 Cyl 2.5L Duratec HE PFI, 4 Cyl 2.5L PFI Gas/Electric | 5-Speed Automatic Transmission Mazda FNR5, 5-Speed Manual Transmission (G5M), 6-Speed Automatic Transaxle - AWF21, 6-Speed Automatic Transmission 6F Mid-Range, 6-Speed Automatic Transmission 6F55, 6-Speed Manual Transmission - B6, 6-Speed Manual Transmission Mazda G6M, CVT Auto Trans Powersplit Elec, ECVT Auto Trans Power Split, Four-Wheel Drive (Full Time) (Left Hand Drive), Front-Wheel Drive (Left Hand Drive), Left Hand Drive

| Page 1 of 2 |Next >

1-20 of 21 Results

Ford Fusion Timing Chain Tensioner

The Timing Chain Tensioner in the Ford Fusion automobiles is designed to hold the timing chain at the right tension that is essential for the proper operations of the engine parts. Incorporate into the above points the physiological role played by the Timing Chain Tensioner so that it is able to maintain the right tension which enables the engine to run smoothly. The following may be some of the types of Timing Chain Tensioners that Ford Fusion models may use depending on their operational mechanisms, These tensioners are critical to avoiding problems that may be occasioned by either inadequate tension, or perhaps, overly high tension, hence improving the engine efficiency and durability. In general, the Timing Chain Tensioner plays a crucial role in Ford Fusion vehicles to maintain the standard functionality of the car engine irrespective of the model years.

We provide a wide range of Ford Fusion Timing Chain Tensioner at the best prices possible. If you need Ford Fusion Timing Chain Tensioner, you can shop with confidence on our website. All our OEM parts come with a manufacturer's warranty and are delivered to your door step with a fast delivery service.

Ford Fusion Timing Chain Tensioner Parts Questions & Experts Answers

Tensioner - Timing Belt
1S7Z-6K254-AA
Q: How to remove and install the timing chain cover,Timing Chain and Timing Chain Tensioner in 2.0L,2.3L and 2.5L engine on Ford Fusion?
A: To remove the timing cover, first disconnect the negative battery cable. Loosen the water pump pulley bolts, then remove the drivebelt and drivebelt idler pulley along with the water pump pulley. Next, remove the Crankshaft Pulley, ensuring the engine remains at TDC with the valve cover removed. Disconnect the Crankshaft Position (CKP) sensor electrical connector and remove the sensor, noting that a new sensor must be installed each time it is removed, using the special alignment tool provided. Support the engine from above and raise it enough to remove the right Engine Mount. Disconnect the electrical connector to the power steering pressure switch, unbolt the power steering pump without disconnecting the hoses, and remove the crankshaft front oil seal. Finally, remove the bolts and the timing cover. For installation, reverse the removal steps while ensuring to clean the mating surfaces, apply a 2.5 mm bead of RTV sealant within four minutes, tighten the bolts in sequence, install a new crankshaft front oil seal, re-time the engine, and use a new crankshaft position sensor with the alignment tool, ensuring not to tighten the sensor mounting bolts until the tool is in place. To remove the timing chain and tensioner, first remove the timing cover, then compress the timing chain tensioner and insert a pin to hold it in the compressed position, being cautious not to compress the ratchet mechanism. Remove the two tensioner mounting bolts and the tensioner, followed by the loose timing chain guide and timing chain. If necessary, remove the left chain guide and camshaft sprockets. For installation, remove the camshaft alignment tool if installed, loosen but do not remove the camshaft phaser and sprocket bolts, and hold the camshaft while turning the sprocket bolt. Install the left chain guide if removed, followed by the timing chain and right chain guide. Install the timing chain tensioner, tighten the fasteners, and remove the pin to release the tensioner. Finally, install the camshaft alignment tool and tighten the camshaft sprocket bolts while holding the camshafts in place. The timing cover can now be installed.

Related Ford Fusion Parts

Browse by Year

2020 Timing Chain Tensioner 2019 Timing Chain Tensioner 2018 Timing Chain Tensioner 2017 Timing Chain Tensioner 2016 Timing Chain Tensioner 2015 Timing Chain Tensioner 2014 Timing Chain Tensioner 2013 Timing Chain Tensioner 2012 Timing Chain Tensioner 2011 Timing Chain Tensioner 2010 Timing Chain Tensioner 2009 Timing Chain Tensioner 2008 Timing Chain Tensioner 2007 Timing Chain Tensioner 2006 Timing Chain Tensioner