How to verify and diagnose a fuel pump defect on 1993-2011 Ford Ranger?

To begin troubleshooting an assumed fuel pump failure, look for gas in the tank. A defective electric fuel pump leads to reduced fuel flow or pressure, which results in poor performance or engine not running at all. These are some steps to take to ascertain whether the pump is operating properly, open the fuel filler cap and have a friend switch on the ignition key while listening for a short whine as the system gets pressurized. The circuit will be the issue if this fails to provoke any movement from it. For testing purposes, use a fuel pressure gauge on the test port and compare readings at certain points. In return-type systems, test pressure at idle and perform further checks such as disconnecting the vacuum hose from the fuel pressure regulator. In return-less models, fix your gauge between that point where you disconnect delivery hose and where fuel rail is connected.

How to remove and install a Fuel Pump on 1993-2011 Ford Ranger?

Remove the fuel tank. Remove any dirt that has accumulated where the fuel sender/pump is attached to the fuel tank. Don't allow dirt to enter the fuel tank. Tum the lock ring counterclockwise with lock/ring wrench (or other suitable tool) until It's loose. Remove the lock ring. Carefully pull the fuel pump/sending unit assembly from the tank. Don't bend the arm for the sending unit float. Remove the old lock ring seal and discard it. Clean the fuel pump mounting flange, the tan mounting surface and seal ring groove. Installation is the reverse of the removal procedure with the following additions: Apply a thin coat of heavy grease to the new lock ring seal to hold it in place during assembly. Install the seal in the lock ring groove. Install the fuel sender/pump unit into the fuel tank so that the tabs of the unit are positioned into the slots in the fuel tank. Make sure to keep the seal in place during installation until the lock ring has been tightened properly. Hold the fuel sender/pump unit in place, install and tighten the locking ring clockwise with the lock ring wrench, or equivalent, until the stop is against the retainer ring tab.

Genuine Ford Ranger Fuel Pump

Gas Pump

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

40 Fuel Pumps found

View related parts
Ford Ranger Kit
Part Number: 6L5Z-9H307-C
$279.41 MSRP: $456.36
You Save: $176.95 (39%)
ADD TO CART
Product Specifications
- Manufacturer Note: kit Includes Pump Asy, Sketch And Insulator
- Replaced by: 6L5Z-9H307-F
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2004-2006 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Kit
Part Number: 8L5Z-9H307-D
$334.63 MSRP: $558.18
You Save: $223.55 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Fuel Pump, Fuel Sender Unit
- Manufacturer Note: kit Includes Pump Asy, Sketch And Insulator
- Replaces: 7L5Z-9H307-A, PFS-519, AL5Z-9H307-A, 8L5Z-9H307-A, PFS-558
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2011 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Sender And Pump Assembly
Part Number: 8L5Z-9H307-A
$334.63 MSRP: $558.18
You Save: $223.55 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Sender And Pump Assy
- Replaced by: 8L5Z-9H307-D
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2008-2011 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Sender And Pump Assembly
Part Number: 8L5Z-9H307-C
$277.19 MSRP: $452.73
You Save: $175.54 (39%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Sender And Pump Assy
- Replaced by: 8L5Z-9H307-F
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2008-2011 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Sender And Pump Assembly
Part Number: 7L5Z-9H307-C
$271.41 MSRP: $452.73
You Save: $181.32 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Sender And Pump Assy
- Replaced by: 8L5Z-9H307-F
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2008 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Kit
Part Number: 6L5Z-9H307-A
$265.96 MSRP: $443.64
You Save: $177.68 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Manufacturer Note: kit Includes Pump Asy, Sketch And Insulator
- Replaced by: 6L5Z-9H307-D
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2004-2006 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Sender And Pump Assembly
Part Number: 6L5Z-9H307-CA
$279.41 MSRP: $456.36
You Save: $176.95 (39%)
ADD TO CART
Product Specifications
- Other Name: Sender And Pump Assy
- Replaced by: 6L5Z-9H307-F
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2006 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger SENDER ASY - FUEL TANK
Part Number: KB3Z-9A299-C
$20.75 MSRP: $33.09
You Save: $12.34 (38%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Fuel Gauge Sending Unit, Level Sensor
- Replaces: KB3Z-9A299-B, PS-1082, KB3Z-9A299-A
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2019-2023 Ford Ranger | 4 Cyl 2.3 L GAS, 4 Cyl 2.3L TIVCT DI TC | 10-Speed Automatic Transmission (10R80), 2 Whl L/H Rear Drive-High Ride, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive
View related parts
Ford Ranger Sender And Pump Assembly
Part Number: 3L5Z-9H307-EA
$211.46 MSRP: $352.73
You Save: $141.27 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Sender And Pump Assy
- Manufacturer Note: 118" WB, 2.3L, 3.0L, 4.0L, FROM 8/1/2003
- Replaced by: 3L5Z-9H307-ED
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003 Ford Ranger | 4 Cyl 2.3L, 6 Cyl 3.0L, 6 Cyl 4.0L | 5AT 5R44E, 5AT 5R55E, 5MT
View related parts
Ford Ranger Sender And Pump Assembly
Part Number: 3L5Z-9H307-EC
$211.46 MSRP: $352.73
You Save: $141.27 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Sender And Pump Assy
- Manufacturer Note: Service Fix, 118" WB, 2.3L, 3.0L, 4.0L, FROM 8/1/2003
- Replaced by: 3L5Z-9H307-ED
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003 Ford Ranger | 4 Cyl 2.3L, 6 Cyl 3.0L, 6 Cyl 4.0L | 5AT 5R44E, 5AT 5R55E, 5MT
View related parts
Ford Ranger Sender And Pump Assembly
Part Number: 6L5Z-9H307-AA
$265.96 MSRP: $443.64
You Save: $177.68 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Sender And Pump Assy
- Replaced by: 6L5Z-9H307-D
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2006 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Sender And Pump Assembly
Part Number: 7L5Z-9H307-A
$334.63 MSRP: $558.18
You Save: $223.55 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Sender And Pump Assy
- Replaced by: 8L5Z-9H307-D
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2008 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Sender And Pump Assembly
Part Number: 8L5Z-9H307-B
$270.32 MSRP: $450.91
You Save: $180.59 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Sender And Pump Assy
- Replaced by: 8L5Z-9H307-E
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2008-2011 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger SENDER ASY - FUEL TANK
Part Number: KB3Z-9A299-A
$20.75 MSRP: $33.09
You Save: $12.34 (38%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Replaced by: KB3Z-9A299-C
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2019 Ford Ranger | 4 Cyl 2.3L TIVCT DI TC | 10-Speed Automatic Transmission (10R80), 2 Whl L/H Rear Drive-High Ride, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive
View related parts
Ford Ranger Kit
Part Number: 8L5Z-9H307-E
$270.32 MSRP: $450.91
You Save: $180.59 (41%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Fuel Pump, Fuel Sender Unit
- Manufacturer Note: kit Includes Pump Asy, Sketch And Insulator
- Replaces: 8L5Z-9H307-B, PFS-520
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2011 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Fuel Pump Assembly
Part Number: K2GZ-9350-A
$159.60 MSRP: $233.33
You Save: $73.73 (32%)
ADD TO CART
Product Specifications
- Other Name: Pump Assembly - Fuel; Fuel Pump
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2019-2023 Ford Ranger | 4 Cyl 2.3 L GAS, 4 Cyl 2.3L TIVCT DI TC | 10-Speed Automatic Transmission (10R80), 2 Whl L/H Rear Drive-High Ride, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive
View related parts
Ford Ranger SENDER AND PUMP ASY
Part Number: KB3Z-9H307-E
$400.02 MSRP: $643.64
You Save: $243.62 (38%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Fuel Pump
- Replaces: KB3Z-9H307-A, KB3Z-9H307-D, KB3Z-9H307-C, PFS-1324, KB3Z-9H307-B
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2019-2023 Ford Ranger | 4 Cyl 2.3 L GAS, 4 Cyl 2.3L TIVCT DI TC | 10-Speed Automatic Transmission (10R80), 2 Whl L/H Rear Drive-High Ride, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive
View related parts
Ford Ranger SENDER AND PUMP ASY
Part Number: KB3Z-9H307-A
$400.02 MSRP: $643.64
You Save: $243.62 (38%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Replaced by: KB3Z-9H307-E
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2019 Ford Ranger | 4 Cyl 2.3L TIVCT DI TC | 10-Speed Automatic Transmission (10R80), 2 Whl L/H Rear Drive-High Ride, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive
View related parts
Ford Ranger SENDER AND PUMP ASY
Part Number: KB3Z-9H307-B
$400.02 MSRP: $643.64
You Save: $243.62 (38%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Replaced by: KB3Z-9H307-E
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2019 Ford Ranger | 4 Cyl 2.3L TIVCT DI TC | 10-Speed Automatic Transmission (10R80), 2 Whl L/H Rear Drive-High Ride, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive
View related parts
Ford Ranger Kit
Part Number: 8L5Z-9H307-F
$281.37 MSRP: $452.73
You Save: $171.36 (38%)
Product Specifications
- Other Name: Fuel Pump, Fuel Sender Unit
- Manufacturer Note: kit Includes Pump Asy, Sketch And Insulator
- Replaces: 7L5Z-9H307-C, AL5Z-9H307-C, 8L5Z-9H307-C, PFS-521, PFS-560
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2011 Ford Ranger | 4 Cyl 2.3L NA Petrol, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)

| Page 1 of 2 |Next >

1-20 of 40 Results

Ford Ranger Fuel Pump

The Ford Ranger Fuel Pump, is also a very important part in the system that delivers the fuel from the tank to the carburetor or the fuel injector. Some of them include the mechanical pump and the electric pump among others have been used through the years. Bulb-type mechanical pumps are employed usefully in carbureted engines and are low-pressure, driven from the camshaft. As for the electric pumps, injected in fuel injected engines, the pressure is higher and the function is controlled by the ECUs. Most of the modern electric pumps incorporate the technology of pulse-width modulation to both increase the product's durability and minimize power loss, which contributes to maximum engine performance and emission standards. Some of the signs include a fuel pump whining, surging, and an engine that fails to start; these require correct diagnostics and installation depending on the engine and the fuel system requirements.

We provide a wide range of Ford Ranger Fuel Pump at the best prices possible. If you need Ford Ranger Fuel Pump, you can shop with confidence on our website. All our OEM parts come with a manufacturer's warranty and are delivered to your door step with a fast delivery service.

Ford Ranger Fuel Pump Parts Questions & Experts Answers

Kit
8L5Z-9H307-D
Q: How to verify and diagnose a fuel pump defect on 1993-2011 Ford Ranger?
A: To begin troubleshooting an assumed fuel pump failure, look for gas in the tank. A defective electric fuel pump leads to reduced fuel flow or pressure, which results in poor performance or engine not running at all. These are some steps to take to ascertain whether the pump is operating properly, open the fuel filler cap and have a friend switch on the ignition key while listening for a short whine as the system gets pressurized. The circuit will be the issue if this fails to provoke any movement from it. For testing purposes, use a fuel pressure gauge on the test port and compare readings at certain points. In return-type systems, test pressure at idle and perform further checks such as disconnecting the vacuum hose from the fuel pressure regulator. In return-less models, fix your gauge between that point where you disconnect delivery hose and where fuel rail is connected.
Kit
8L5Z-9H307-D
Q: How to remove and install a Fuel Pump on 1993-2011 Ford Ranger?
A: Remove the Fuel Tank. Remove any dirt that has accumulated where the fuel sender/pump is attached to the fuel tank. Don't allow dirt to enter the fuel tank. Tum the lock ring counterclockwise with lock/ring wrench (or other suitable tool) until It's loose. Remove the lock ring. Carefully pull the fuel pump/sending unit assembly from the tank. Don't bend the arm for the sending unit float. Remove the old lock ring seal and discard it. Clean the fuel pump mounting flange, the tan mounting surface and seal ring groove. Installation is the reverse of the removal procedure with the following additions: Apply a thin coat of heavy grease to the new lock ring seal to hold it in place during assembly. Install the seal in the lock ring groove. Install the fuel sender/pump unit into the fuel tank so that the tabs of the unit are positioned into the slots in the fuel tank. Make sure to keep the seal in place during installation until the lock ring has been tightened properly. Hold the fuel sender/pump unit in place, install and tighten the locking ring clockwise with the lock ring wrench, or equivalent, until the stop is against the retainer ring tab.