What precautions should be taken when working with Supplemental Restraint systems (SRS) and how do you check and replace the headlight switch on Ford Expedition?

The models covered are equipped with Supplemental Restraint systems (SRS), commonly known as airbags. Always disconnect the negative battery cable followed by the positive battery cable and wait two minutes before working near the impact sensors, steering column, or instrument panel to avoid accidental airbag deployment, which could cause personal injury. To check the switch, it must first be removed. Using an ohmmeter or self-powered test light along with the accompanying diagrams, check for continuity between the indicated switch terminals in each of the specified positions. If continuity is not as specified, replace the switch. For 2002 and earlier models, disconnect the negative battery cable, turn the headlight switch to the ON position, and pull the knob outward to the fog light ON position. Use a small screwdriver to pry the knob off the headlight switch, ensuring the knob is positioned so that the headlights and fog lights are ON. Turn the knob 180 degrees from the ON position and reinstall it back onto the headlight switch. Turn the headlight switch to the OFF position, then rotate the knob clockwise as far as possible while holding it to enable the locking tab on the back of the switch to retract, allowing the headlight switch to be removed from the instrument panel. Unplug the electrical connector from the back of the switch and remove it from the vehicle, with installation being the reverse of removal. For 2003 and later models, remove the driver's knee bolster. On models with a removable switch panel, pry the panel out, disconnect the electrical connectors, and remove the screws securing the switch to the back of the panel. On models where the switch is mounted to the instrument panel, disconnect the electrical connector from behind and release the tabs securing the switch to the instrument panel.

Genuine Ford Expedition Headlight Switch

Headlamp Switch

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

24 Headlight Switches found

View related parts
Ford Expedition Switch Assembly - Headlamps
Part Number: DG9Z-11654-BA
$55.00 MSRP: $90.91
You Save: $35.91 (40%)
ADD TO CART
Product Specifications
- Other Name: Headlamp Switch
- Manufacturer Note: BLACK
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2018-2021 Ford Expedition | 6 Cyl 3.5 L GAS, 6 Cyl 3.5L GTDI | 10-Speed Automatic Transmission (10R80), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Expedition Switch Assembly - Headlamps
Part Number: AL3Z-11654-CB
$46.40 MSRP: $72.73
You Save: $26.33 (37%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Switch Assy - Headlamps; Headlamp Switch
- Manufacturer Note: BLACK
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2015-2017 Ford Expedition | 6 Cyl 3.5L GTDI, 8 Cyl 5.4L | 4AT 4R75W, 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 6-Speed Automatic Transmission (6R75), 6-Speed Automatic Transmission (6R80), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Expedition Switch Assembly - Headlamps
Part Number: 7L1Z-11654-CA
$36.60 MSRP: $72.73
You Save: $36.13 (50%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Switch Assy - Headlamps; Headlamp Switch
- Manufacturer Note: BLACK
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2014 Ford Expedition | 8 Cyl 5.4L | 4AT 4R75W, 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 6-Speed Automatic Transmission (6R75), 6-Speed Automatic Transmission (6R80), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Expedition Switch Assembly
Part Number: XL3Z-11654-AAA
$184.85 MSRP: $252.58
You Save: $67.73 (27%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Switch Assy; Headlamp Switch
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1999 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W
View related parts
Ford Expedition Switch Assembly - Headlamps
Part Number: 7L1Z-11654-BA
$13.28 MSRP: $18.45
You Save: $5.17 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Switch Assy - Headlamps; Headlamp Switch
- Manufacturer Note: BLACK
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2007-2014 Ford Expedition | 8 Cyl 5.4L | 4AT 4R75W, 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 6-Speed Automatic Transmission (6R75), 6-Speed Automatic Transmission (6R80), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Expedition Switch Assembly
Part Number: F85Z-11654-DAA
$275.88 MSRP: $383.24
You Save: $107.36 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Switch Assy; Headlamp Switch
- Replaces: F65Z-11654-AAD
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1997-1998 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W, 4AT E4OD
View related parts
Ford Expedition SWITCH ASY - HEADLAMPS
Part Number: NL1Z-11654-AB
$71.82 MSRP: $114.55
You Save: $42.73 (38%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp Switch
- Replaces: NL1Z-11654-AA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2022-2024 Ford Expedition | 6 Cyl 3.5 L FLEX, 6 Cyl 3.5 L GAS
View related parts
Ford Expedition SWITCH ASY - HEADLAMPS
Part Number: LJ6Z-11654-BD
$57.00 MSRP: $90.91
You Save: $33.91 (38%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp Switch
- Replaces: LJ6Z-11654-BC, SW-8739, LJ6Z-11654-BB, SW-8715
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2022-2024 Ford Expedition | 6 Cyl 3.5 L FLEX, 6 Cyl 3.5 L GAS
View related parts
Ford Expedition SWITCH ASY - HEADLAMPS
Part Number: NL1Z-11654-CB
$71.82 MSRP: $114.55
You Save: $42.73 (38%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Headlamp Switch
- Replaces: NL1Z-11654-CA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2022-2024 Ford Expedition | 6 Cyl 3.5 L FLEX, 6 Cyl 3.5 L GAS
View related parts
Ford Expedition Switch Assembly - Headlamps
Part Number: AL3Z-11654-BA
$46.40 MSRP: $72.73
You Save: $26.33 (37%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Switch Assy - Headlamps; Headlamp Switch
- Manufacturer Note: BLACK
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2015-2017 Ford Expedition | 6 Cyl 3.5L GTDI, 8 Cyl 5.4L | 4AT 4R75W, 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 6-Speed Automatic Transmission (6R75), 6-Speed Automatic Transmission (6R80), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Expedition Switch Assembly
Part Number: F65Z-11654-AAB
Product Specifications
- Other Name: SWITCH ASY
- Replaced by: F85Z-11654-BAA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1997-1998 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W, 4AT E4OD
View related parts
Ford Expedition Switch Assembly
Part Number: F85Z-11654-AAA
Product Specifications
- Other Name: Switch Assy; Headlamp Switch
- Replaces: F65Z-11654-AAA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1997-1998 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W, 4AT E4OD
View related parts
Ford Expedition Switch Assembly
Part Number: YL3Z-11654-BAB
Product Specifications
- Other Name: Switch Assy; Headlamp Switch
- Manufacturer Note: Black, 'PULL FOR FOG', With front fog lamps, with conventional headlamp control
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2000-2002 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W
View related parts
Ford Expedition Switch Assembly
Part Number: F65Z-11654-AAD
Product Specifications
- Other Name: SWITCH ASY
- Replaced by: F85Z-11654-DAA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1997-1998 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W, 4AT E4OD
View related parts
Ford Expedition Switch Assembly
Part Number: 2L1Z-11654-BAB
Product Specifications
- Other Name: Switch Assy
- Replaced by: 4L1Z-11654-BAA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003-2004 Ford Expedition | 8 Cyl 4.6L Romeo SOHC EFI, 8 Cyl 5.4L Modular SOHC | 4AT 4R75W, 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 6-Speed Automatic Transmission (6R75), 6-Speed Automatic Transmission (6R80), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Expedition Switch Assembly - Headlamps
Part Number: 4L1Z-11654-BAA
Product Specifications
- Other Name: Switch Assy - Headlamps; Headlamp Switch, Light Switch, Switch Assembly
- Replaces: 2L1Z-11654-BAB
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2003-2006 Ford Expedition | 8 Cyl 4.6L Romeo SOHC EFI, 8 Cyl 5.4L, 8 Cyl 5.4L Modular SOHC | 4-Speed Automatic Transmission 4R70W (AODE), 4-Speed Automatic Transmission 4R75E Livonia, 4-Speed Automatic Transmission AODEW/4R75E W/TSS, 4AT 4R75W, 6-Speed Automatic Transmission (6R75), 6-Speed Automatic Transmission (6R80), Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Expedition Switch Assembly
Part Number: F65Z-11654-AAA
Product Specifications
- Other Name: Switch Assy
- Replaced by: F85Z-11654-AAA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1997-1998 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W, 4AT E4OD
View related parts
Ford Expedition Switch Assembly
Part Number: F85Z-11654-BAA
Product Specifications
- Other Name: Switch Assy; Headlamp Switch
- Replaces: F65Z-11654-AAB
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1997-1998 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W, 4AT E4OD
View related parts
Ford Expedition Switch Assembly
Part Number: XL3Z-11654-BAA
Product Specifications
- Other Name: Switch Assy; Headlamp Switch
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1999 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W
View related parts
Ford Expedition Switch Assembly
Part Number: YL3Z-11654-AAB
Product Specifications
- Other Name: Switch Assy; Headlamp Switch
- Manufacturer Note: Black, Less front fog lamps, with conventional headlamp control
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2000-2002 Ford Expedition | 8 Cyl 4.6L, 8 Cyl 5.4L | 4AT 4R100, 4AT 4R70W

| Page 1 of 2 |Next >

1-20 of 24 Results

Ford Expedition Headlight Switch

We provide a wide range of Ford Expedition Headlight Switch at the best prices possible. If you need Ford Expedition Headlight Switch, you can shop with confidence on our website. All our OEM parts come with a manufacturer's warranty and are delivered to your door step with a fast delivery service.

Ford Expedition Headlight Switch Parts Questions & Experts Answers

Switch Assembly
XL3Z-11654-BAA
Q: What precautions should be taken when working with Supplemental Restraint systems (SRS) and how do you check and replace the headlight switch on Ford Expedition?
A: The models covered are equipped with Supplemental Restraint systems (SRS), commonly known as airbags. Always disconnect the negative battery cable followed by the positive battery cable and wait two minutes before working near the impact sensors, steering column, or instrument panel to avoid accidental airbag deployment, which could cause personal injury. To check the switch, it must first be removed. Using an ohmmeter or self-powered test light along with the accompanying diagrams, check for continuity between the indicated switch terminals in each of the specified positions. If continuity is not as specified, replace the switch. For 2002 and earlier models, disconnect the negative battery cable, turn the headlight switch to the ON position, and pull the knob outward to the fog light ON position. Use a small screwdriver to pry the knob off the headlight switch, ensuring the knob is positioned so that the headlights and fog lights are ON. Turn the knob 180 degrees from the ON position and reinstall it back onto the headlight switch. Turn the headlight switch to the OFF position, then rotate the knob clockwise as far as possible while holding it to enable the locking tab on the back of the switch to retract, allowing the headlight switch to be removed from the instrument panel. Unplug the electrical connector from the back of the switch and remove it from the vehicle, with installation being the reverse of removal. For 2003 and later models, remove the driver's knee bolster. On models with a removable switch panel, pry the panel out, disconnect the electrical connectors, and remove the screws securing the switch to the back of the panel. On models where the switch is mounted to the instrument panel, disconnect the electrical connector from behind and release the tabs securing the switch to the instrument panel.