How do you remove and install a radiator on 1993-2011 Ford Ranger?

To replace the radiator, remove the negative battery cable and drain the coolant. Similarly, be careful when removing or loosening radiator hoses from their fittings to prevent distortion. If necessary, cut off old or worn-out hoses and put new ones in their place. Remove screws holding fan shroud and slide it towards the engine. In the case of vehicles with automatic transmission, disconnect transmission cooler lines by using the backup wrench to hold the fittings and then plug them to avoid leaks. Detach all radiator mounting sockets before carefully lifting it from its lower mounting pads. Blow through with compressed air, brush gently with a soft brush or check for leaks, and damage or clean up if necessary, bleed if needed. Check your radiator mounts for wear and tear. Fill the cooling system, start the engine, bleed if necessary, and check for leaks at the operating temperature.

How do you remove and install a radiator on 2000-2011 Ford Ranger?

To replace the radiator, disconnect the negative battery cable and drain the coolant if clean. Loosen hose clamps, detach radiator hoses without distorting fittings. Replace old hoses. Disconnect reservoir hose. Remove screws attaching fan shroud to radiator and slide it towards the engine. Disconnect transmission cooler lines if applicable. Plug lines and fittings. Remove radiator mounting bolts and lift it out carefully. Inspect for leaks and damage. Clean radiator with compressed air and brush. Check mounts for deterioration and debris. For installation, reverse removal procedure, fill cooling system with antifreeze-water mixture, check for leaks, and let engine reach normal temperature. Recheck coolant levels and add more if needed. Also check and add transmission fluid if applicable.

Genuine Ford Ranger Radiator

Cooling Radiator

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

44 Radiators found

View related parts
Ford Ranger Radiator Assembly
Part Number: XL2Z-8005-LA
$321.14 MSRP: $491.03
You Save: $169.89 (35%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Assy
- Replaced by: 6L5Z-8005-DA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2000-2005 Ford Ranger | 6 Cyl 3.0L, 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L, 6 Cyl 4.0L SOHC EFI | 4AT 4R44E, 5AT 5R44E, 5AT 5R55E, 5MT, 5-Speed Automatic Transmission - 5R44E/5R55E, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Radiator Assembly
Part Number: F87Z-8005-GA
$485.70 MSRP: $674.72
You Save: $189.02 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Assy; Radiator
- Manufacturer Note: #F87H 8005,GA , All Automatic
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1998-2001 Ford Ranger | 4 Cyl 2.5L | 4AT 4R44E, 5AT 5R44E, 5AT 5R55E, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: 1L5Z-8005-MA
$321.14 MSRP: $491.03
You Save: $169.89 (35%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Assy
- Manufacturer Note: #1L5H 8005-MA, SOHC - M/T
- Replaced by: 6L5Z-8005-DA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2001-2003 Ford Ranger | 6 Cyl 4.0L | 4AT 4R44E, 5AT 5R44E, 5AT 5R55E, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: F67Z-8005-CA
$369.66 MSRP: $513.52
You Save: $143.86 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Assy; Radiator
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1998-2001 Ford Ranger | 4 Cyl 2.3L, 4 Cyl 2.5L, 6 Cyl 3.0L, 6 Cyl 4.0L | 4AT 4R44E, 5AT 5R44E, 5AT 5R55E, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: 6L5Z-8005-CA
$214.93 MSRP: $317.00
You Save: $102.07 (33%)
ADD TO CART
Product Specifications
- Other Name: Radiator Assy; Radiator
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2006-2011 Ford Ranger | 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Radiator Assembly
Part Number: KB3Z-8005-A
$312.72 MSRP: $461.23
You Save: $148.51 (33%)
Ships in 1 Business Day
ADD TO CART
Product Specifications
- Other Name: Radiator
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2019-2023 Ford Ranger | 4 Cyl 2.3 L GAS, 4 Cyl 2.3L TIVCT DI TC | 10-Speed Automatic Transmission (10R80), 2 Whl L/H Rear Drive-High Ride, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive
View related parts
Ford Ranger Radiator Assembly
Part Number: F5UZ-8005-B
$515.48 MSRP: $716.09
You Save: $200.61 (29%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Assy; Radiator
- Manufacturer Note: WITH A/C
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1983-1989 Ford Ranger | 4 Cyl 2.0L, 4 Cyl 2.2L, 4 Cyl 2.3L, 6 Cyl 2.8L, 6 Cyl 2.9L | 3AT C3, 3AT C5, 4AT A4LD, 4MT, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: 6L5Z-8005-AA
$270.21 MSRP: $398.53
You Save: $128.32 (33%)
ADD TO CART
Product Specifications
- Other Name: Radiator Assy; Radiator
- Replaces: 4L5Z-8005-AA, 6L5Z-8005-BA, 4L5Z-8005-BA, RAD-24
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2005-2011 Ford Ranger | 4 Cyl 2.3L NA Petrol | 5-Speed Automatic Transmission - 5R44E/5R55E, 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Radiator Assembly
Part Number: 4L5Z-8005-AA
$270.21 MSRP: $398.53
You Save: $128.32 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Assy
- Replaced by: 6L5Z-8005-AA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2005 Ford Ranger | 4 Cyl 2.3L NA Petrol | 5-Speed Automatic Transmission - 5R44E/5R55E, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Radiator Assembly
Part Number: 6L5Z-8005-BA
$270.21 MSRP: $398.53
You Save: $128.32 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Assy
- Replaced by: 6L5Z-8005-AA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2006-2011 Ford Ranger | 4 Cyl 2.3L NA Petrol | 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Radiator Assembly
Part Number: 4L5Z-8005-BA
$270.21 MSRP: $398.53
You Save: $128.32 (33%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: Radiator Assy
- Replaced by: 6L5Z-8005-AA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2005 Ford Ranger | 4 Cyl 2.3L NA Petrol | 5-Speed Manual Transmission - R1HD, 5-Speed Manual Transmission M5R1, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Radiator Assembly
Part Number: FOTZ-8005-CA
$0.00
Product Specifications
- Other Name: Radiator Assy; Radiator
- Manufacturer Note: #F17H 8005-GA
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1990-1994 Ford Ranger | 6 Cyl 2.9L, 6 Cyl 3.0L, 6 Cyl 4.0L | 4AT A4LD, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: 1L5Z-8005-JA
Product Specifications
- Other Name: Radiator Assy; Radiator
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2001 Ford Ranger | 6 Cyl 4.0L | 4AT 4R44E, 5AT 5R44E, 5AT 5R55E, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: 1L5Z-8005-NA
Product Specifications
- Other Name: Radiator Assy; Radiator
- Manufacturer Note: #1L5H 8005-NA, A/T
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2001-2003 Ford Ranger | 6 Cyl 4.0L | 4AT 4R44E, 5AT 5R44E, 5AT 5R55E, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: 6L5Z-8005-DACP
Product Specifications
- Other Name: Radiator Assy; Radiator
- Manufacturer Note: (CP) Designates Crash Part - When Ordering Please Refer To Crash Part Truckload Program Guidelines
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 2006-2011 Ford Ranger | 6 Cyl 3.0L OHV EFI, 6 Cyl 4.0L SOHC EFI | 5-Speed Automatic Transmission - 5R44E/5R55E, Four-Wheel Drive (Part Time) (Left Hand Drive), Left Hand Drive, Rear-Wheel Drive (Left Hand Drive)
View related parts
Ford Ranger Radiator Assembly
Part Number: E7TZ-8005-D
Product Specifications
- Other Name: Radiator
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1983-1990 Ford Ranger | 4 Cyl 2.0L, 4 Cyl 2.2L, 4 Cyl 2.3L, 6 Cyl 2.8L, 6 Cyl 2.9L, 6 Cyl 4.0L | 3AT C3, 3AT C5, 4AT A4LD, 4MT, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: E9TZ-8005-K
Product Specifications
- Other Name: RADIATOR ASY
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1983-1990 Ford Ranger | 4 Cyl 2.0L, 4 Cyl 2.2L, 4 Cyl 2.3L, 6 Cyl 2.8L, 6 Cyl 2.9L | 3AT C3, 3AT C5, 4AT A4LD, 4MT, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: E9TZ-8005-L
Product Specifications
- Other Name: RADIATOR ASY
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1983-1989 Ford Ranger | 4 Cyl 2.0L, 4 Cyl 2.2L, 4 Cyl 2.3L, 6 Cyl 2.8L, 6 Cyl 2.9L | 3AT C3, 3AT C5, 4AT A4LD, 4MT, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: F1TZ-8005-A
Product Specifications
- Other Name: RADIATOR ASY
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1992-1997 Ford Ranger | 6 Cyl 4.0L | 4AT 4R44E, 4AT 4R55E, 4AT A4LD, 5AT 5R55E, 5MT
View related parts
Ford Ranger Radiator Assembly
Part Number: F1TZ-8005-C
Product Specifications
- Other Name: RADIATOR ASY
- Manufacturer Note: Super cooling pkg., A/T - std. cooling - with A/C
- Warranty: This genuine part is guaranteed by Ford's factory warranty.
Fits the following Vehicles:
- 1991 Ford Ranger | 6 Cyl 3.0L | 4AT A4LD, 5MT

| Page 1 of 3 |Next >

1-20 of 44 Results

Ford Ranger Radiator

Ford Ranger Radiator is an important component of the cooling system of the vehicle; it aids in dissipating heat from the engine antifreeze to the surroundings. Often consisting of fins and tubes located in the center profile, the radiator is installed in the car's front section to benefit from sheer air flow. Most radiators are made up of aluminum core, however, there are models that are made up of copper/brass. performance radiators are superior to stock ones, made of lightweight aluminum and having better designs for better cooling. It is important to identify the early signs of a problem with the radiator that can cause leakage, variation in temperature or have discolored coolant that may harm the engine. Another common method of improving the life of the Ford Ranger Radiator is by flushing the radiator and using the correct coolant type in the vehicle.

We provide a wide range of Ford Ranger Radiator at the best prices possible. If you need Ford Ranger Radiator, you can shop with confidence on our website. All our OEM parts come with a manufacturer's warranty and are delivered to your door step with a fast delivery service.

Ford Ranger Radiator Parts Questions & Experts Answers

Radiator Assembly
XL2Z-8005-LA
Q: How do you remove and install a radiator on 1993-2011 Ford Ranger?
A: To replace the radiator, remove the negative battery cable and drain the coolant. Similarly, be careful when removing or loosening radiator hoses from their fittings to prevent distortion. If necessary, cut off old or worn-out hoses and put new ones in their place. Remove screws holding fan shroud and slide it towards the engine. In the case of vehicles with automatic transmission, disconnect transmission cooler lines by using the backup wrench to hold the fittings and then plug them to avoid leaks. Detach all radiator mounting sockets before carefully lifting it from its lower mounting pads. Blow through with compressed air, brush gently with a soft brush or check for leaks, and damage or clean up if necessary, bleed if needed. Check your radiator mounts for wear and tear. Fill the cooling system, start the engine, bleed if necessary, and check for leaks at the operating temperature.
Radiator Assembly
XL2Z-8005-LA
Q: How do you remove and install a radiator on 2000-2011 Ford Ranger?
A: To replace the radiator, disconnect the negative battery cable and drain the coolant if clean. Loosen hose clamps, detach radiator hoses without distorting fittings. Replace old hoses. Disconnect reservoir hose. Remove screws attaching fan shroud to radiator and slide it towards the engine. Disconnect transmission cooler lines if applicable. Plug lines and fittings. Remove radiator mounting bolts and lift it out carefully. Inspect for leaks and damage. Clean radiator with compressed air and brush. Check mounts for deterioration and debris. For installation, reverse removal procedure, fill cooling system with antifreeze-water mixture, check for leaks, and let engine reach normal temperature. Recheck coolant levels and add more if needed. Also check and add transmission fluid if applicable.